同业装备IC厌氧反应器 厌氧反应设备 质量好 可定制

      IC厌氧反应器由于存在着强大的内循环、传质效果好、生物量大、其容积负荷

远比普通的UASB 反应器高，一般可高出3倍左右。处理高浓度有机废水，当COD为10

000-15000mg/1 时，容积负荷率可达10-18CODm3?d。
2、节省基建投资和占地面积
      IC反应器比普通UASB反应器高3倍左右容积负荷率，是普通UASB 反应器占地面

积的1/4-1/3 左右，所以可以降低反应器的基建投资。IC反应器不仅体积小，而且有

很大的高径比，所以占地面积特别省，非常适用于紧张的厂矿企业新、扩建工程。
3、抗冲击负荷能力强
      IC反应器实现了自身的内循环，循环量可达进水的10-20 倍。因为循环水与进

水在反应器底部充分混合，使反应器底部有机物浓度降低，从而提高了反应器的耐冲

击负荷能力；同时大水量也使底部污泥得以均散，保证了废水中的有机物与微生物的

充分接触反应，提高了处理负荷。
4、出水稳定性好
      因为IC反应器相当上下两个UASB 反应器的串联运行，下面一个反应器具有很高

的有机负荷率，起“粗”处理作用，上面一个反应器的负荷低，起“精”处理作用，

使出水水质好且稳定。
1. High Volume Load Rate
      Due to the powerful inner circulation, good mass transfer effect and

large biomass, the inlet water load rate of IC Anaerobic Reactor is 3 time

s higher than ordinary UASB Reactor. When treating high concentration orga

nic wastewater and COD is 10000-15000mg/h, volume load rate can reach 10-1

8CODm3?d.
2. Saving Infrastructure Investment and Floor Occupation
      Volume load rate is 3 times higher than ordinary UASB, but floor occ

upation is only around 1/4-1/3, so that the infrastructure investment of

reactor is lower. Small volume and high aspect ratio make floor occupation

economize. It is very applicable to small industrial enterprises and new e

xpansion project.
3. Powerful Resistance to Impact Load Ability
      It realized the inner circle itself and circulation can reach 10-20

times to inlet water. Circulating water and inlet water's fully mixing ma

ke the concentration of organic matter lower, so that the resistance to

impact load ability is improved. Meanwhile, homodisperse of bottom sludge

insure that organic matter and microbes in wastewater contact and react fu

lly, thus improve processing load ability.
4. Good Outlet Water Stability
      IC Reactor is equivalent to series opera